Change search
ReferencesLink to record
Permanent link

Direct link
Ethanol Production from Cellulosic Biomass by Encapsulated Saccharomyces cerevisiae
University of Borås, School of Engineering.
2008 (English)Doctoral thesis, comprehensive summary (Other academic)
Abstract [en]

Unstable oil markets with rising environmental concerns have revived widespread interest in production of fuel ethanol from renewable materials. Cellulosic materials are abundant and prominent feedstocks for cheap ethanol production. However, due to recalcitrant structure of these materials, pretreatment is a prerequisite. Depending on the biomass, pretreatment and hydrolysis conditions, a number of degradation products and/or toxic components may be released that show strong inhibitory effects on the fermenting microorganisms. This thesis deals with application of encapsulation technology to ferment the highly toxic hydrolyzates without further pretreatment. Free cells could not tolerate presence of 5 g/l furfural in defined medium, and inhibitors in wood and peel hydrolyzates in batch mode of operation and fermentation failed. Continuous cultivation of wood hydrolyzate was only successful at 0.1 h−1 and the majority of cells lost their viability after 5 retention times. Encapsulated cell system could successfully ferment the synthetic medium containing 5 g/l furfural during sequential batch cultivations with ethanol yield of 0.41-0.42 g/g. Cultivation of undetoxified hydrolyzates was also carried out, where glucose and mannose were converted within 10 h without significant lag phase. However, a gradual decrease in cell activity was observed in sequential batches. Continuous cultivation was more successful, and wood hydrolyzate was fermented to ethanol by encapsulated S. cerevisiae at dilution rates up to 0.5 h−1. More than 75% of the encapsulated cells were viable in the worst conditions. Ethanol was produced with yield 0.44 g/g and specific productivity 0.14–0.17 g/g•h at all dilution rates. Contrary to wood hydrolyzate, where there is no preference for permeation of sugars or inhibitors through the capsules’ membrane, encapsulation technology was applied to eliminate inhibition of limonene in fermentation of orange wastes to ethanol. The capsules’ membrane, of hydrophilic nature, is practically impermeable to hydrophobic compounds such as limonene while allowing penetration of nutrients and products. While presence of 0.1% v/v limonene in the medium results in strong inhibition or even failure of cultivation with free cells, using this technique allowed fermentation of a medium containing 1.5% v/v limonene. The impact of encapsulation on the anaerobic growth pattern, morphological and physiological changes of S. cerevisiae over long-term application was investigated. The growth rate, total RNA and protein content of the encapsulated cells decreased gradually over repeated batch cultivations, while stored carbohydrates content increased. Within 20 batch cultivations, total RNA and protein content of encapsulated cells decreased by 39% and 24%, whereas glycogen and trehalose content increased by factors of 4.5 and 4, respectively.

Place, publisher, year, edition, pages
Chalmers University of Technology, Dep. of Chemical and Biological Engineering , 2008.
, Doktorsavhandlingar vid Chalmers tekniska högskola. Ny serie, ISSN 0346-718X ; 2778
Keyword [en]
encapsulated cells, ethanol, s.cerevisiae, dilute-acid hydrolyzate, in situ detoxification, furfural, orange peels, experimental design, immobilization, limonene
National Category
Chemical Engineering
URN: urn:nbn:se:hb:diva-3470Local ID: 2320/3525ISBN: 978-91-7385-097-1OAI: diva2:876859

Akademisk avhandling som för avläggande av teknologie doktorsexamen vid Chalmers tekniska högskola försvaras vid offentlig disputation den 18 april 2008.

Available from: 2015-12-04 Created: 2015-12-04 Last updated: 2016-08-19Bibliographically approved

Open Access in DiVA

fulltext(2770 kB)273 downloads
File information
File name FULLTEXT01.pdfFile size 2770 kBChecksum SHA-512
Type fulltextMimetype application/pdf

Search in DiVA

By author/editor
Talebnia, Farid
By organisation
School of Engineering
Chemical Engineering

Search outside of DiVA

GoogleGoogle Scholar
Total: 273 downloads
The number of downloads is the sum of all downloads of full texts. It may include eg previous versions that are now no longer available

Total: 32 hits
ReferencesLink to record
Permanent link

Direct link